REPLACE PLASTIC POPPET VALVE Caterpillar


`
REPLACE PLASTIC POPPET VALVE [TIBU4213]

CONFIDENTIAL TIBU4213-00

TECHNICAL INFORMATION BULLETIN

April 7, 2004

LOAD HAUL DUMP

R2900G (GLK)

 

Component Code: 4250

SUBJECT: REPLACE PLASTIC POPPET VALVE

PROBLEM:

The plastic poppet valve in the brake charging valve is not achieving an acceptable service life.

SOLUTION:

Change the former plastic poppet valve with a steel poppet valve.

Parts Required

Quantity

Part Number

Description

1

9EQ5772

Poppet Valve

1

162-1575

Repair Kit

 

  1. Release the pressure from the braking system. Refer to Systems Operation Testing and Adjusting, RENR7813, R2900G Load Haul Dump Braking System.

Figure 1

View of the brake charging valve

  1. Screen
  2. Poppet valve
  1. Remove plastic poppet valve (2). Discard plastic poppet valve (2).
  2.  

  3. Remove Screen (1). If screen (1) is damaged, replace the screen.
  4.  

  5. Install new steel poppet valve.
  6.  

  7. Check the brake charging valve cut in and cut out pressures. Refer to Systems Operation Testing and Adjusting, RENR7813, "R2900G Load Haul Dump Braking System".

 

 

COPYRIGHT 2004 AVSpare
ALL RIGHTS RESERVED

Information System:

HOSE WEAR FOR THE MANUAL LOWERING CONTROL VALVE HOSE MAY BE EXPERIENCED
POWER STUD MAY NOT BE ADEQUATELY COVERED TO PREVENT SHOCK HAZARD
Identifying Backhoe Loaders with Foot-Operated Boom Swing Controls that are Referenced in Service Letter SEBE8639
SOS OIL SAMPLE PORT LEAKS
HEATER HOSE WEAR
Water Spray Pump Failure on Large Double Drum Compactors
187-9090 PISTON PUMP FOR SERVICE BRAKE
Changing Model Designations for Certain Skid Steer Loaders and Multi Terrain Loaders With Electronic Technician May Cause the ECM to Disconnect and Lockout the User
THE DOOR STOP FOR THE 233-5962 AND 233-5963 DOOR KITS MAY INTERFERE WITH THE AUXILIARY LINES ON 247 MULTI TERRAIN LOADERS AND 216, 226 SKID STEER LOADERS
Faulty Fuel Priming Pumps on Various Engines
Vibratory Compactor Air Inlet Hose Failures
938GII/IT38GII Alternator Wiring Issue
Valve Bonnets with Insufficient Hardness
Air Filter Fouling on Panel
HYDRAULIC TANK BREATHER HOSE MAY BE CRIMPED INSIDE THE ROPS POST
WEARING OF THE HOSES FOR THE HYDRAULIC OIL FILTER
700 Series Articulated Trucks, Brake Pressure Relief Valve Seal Failure, Fault Diagnosis
NEW ENGINE SOFTWARE FLASH FILES ARE NOW AVAILABLE TO ALLEVIATE UNKNOW OIL PRESSURE SENSOR WARNING INDICATIONS
DRUM DRIVE PLANETARY FAILURES ON THE SOIL COMPACTORS
TRACK DRIVE PLANETARY FAILURES ON THE ASPHALT PAVERS
Missing Oil Caps on Skid Steer Loaders and Multiterrain Loaders.
700 Series Articulated Trucks, Configuration of Dash Information Not Supported by Electronic Technician
Air Intake Tube Rubbing Hydraulic Oil Cooler Lines
OIL IN COOLANT DIAGNOSTIC FOR 3126B, 3126E, AND C7 ENGINES